HomeMy WebLinkAboutADDENDUM - 97-00047 - Madison County - Juvenile Detention Center - RemodelREGION VII
JUVENIL.oE DETENTION FACILITY
m-lomm Ic
ADDEN,DUM #1
OCTOB R 21� 1997
(NOTE: TAE ITEMS 11DENTIFIED IN ADDENDUM #1 FROM THE 30THSE EMBER 1997 BiD
OPENING ARE INCORPORATED HEREIN:)
ITEM 1 BID PROPOSAL Foy:
THE REVISED BID PROPOSAL FORM AS ATTACHED SHALL BE USED BY
GENERAL CONTRACTORS FOR SUBMITTING OF BIDS.
ITEM2 ALTERNATES: (NOTE: DIFFERENT FROM 30T" SEPTEMBER Bm OPENING)
BASE BID: SHALL INCLUDE ALL WORK: (EXCEPT THE OUTDOOR
RECREATION AREA) TO INCLUDE DEMO, REMODEL,
SITEWORK, MECAANICALg ELECT CAL9 ETC. AS SHOWN ON
THE CONTRACT DOCUMENTS AND AS MODIFIED BY THIS
ADDENDUM.
HOLLOW METAL DOORS AND FRAMES SHALL BE 14 GAUGE.
DELETE STRUCTURAL COLUMNS, BEAMS, FOOTINGS, ETC.
SHOWN IN THE BASEMENT AREA ON SHEET A-1, AND
STRUCTURAL SHEETS.
DELETE NEW 2" LIGHTWEIGHT CONCRETE TOPPING SLAB
AS SHOWN ON DRAWINGS.
ADD 12"' X 12" VINYL TILE OVER FLOOR PREP AS SPECIFIED
IN 09681 IN ALL AREAS SHOWN FOR SEALED CONCRETE.
EMERGENCY GENERATOR TO CHANGE FROM 20 KW TO 14
KW, TRANSFER SWITCH TO BE RATED AT 60 AMPS. NEW
SPECS TO REPLACE EXISTING (ENCLOSED).
LoC NG CONTROL SYSTEMS INTERCOM AND PAGING
SYSTEM, MASTER ANTENNA AND CLOSED CIRCUIT T.V.
SYSTEMS TO BE BID SEPARATELY FROM OTHER SYSTEMS,
ALTERNATE #1:
ALTERNATE #20.
ALTERNATE#3,0
ALTERNATE #400
ALTERNATE #510.
ALTERNATE #600
AprjioyEi) AuCEYfABLE 1311)DERS1
LASSCO SOUND & SYSTEMS, INC. AS SPECIFIED
U.S. SYSTEMS, SECURE TECH SYSTEM
TELECT� BASIC 12 SYSTEM
OTHER APPROVED EQUALS**
FIRE ALARM0;
SIMPLEX
HARRINGTON SIGNAL, INC.
FIRE CONTROL INSTRUMENTS
CERBERUS PYROTRONICS
46
EMERGENCY GENERATOR:
SMITH, DETROIT DIESEL ALLUSION
GENERAL POWER SYSTEMS
SHALL BE THE OUTDOOR EXERCISE AREA EXACTLY AS
17:15'/`►[;l►`L�Z.73� �L�l! � 1 D) 1�
SHALL BE THE OUTDOOR RECREATION AREA AS DRAWN ON
THE ATTACHED 8-1/2 X 11 SHEETS.
ALTERNATE LIGHTING FOR OUTDOOR EXERCISE 137.
DELETE FOUR EACH TYPE FS FIXTURES AND INSTALL FOUR
EACH TYPE F7 FIXTURES. MAINTAIN CIRCUITING ANA
NIGHT LIGHT AS SHOWN. MOUNT FIXTURES ON EAST WALL
AS DIRECTED.
6
SHALL IDENTIFY THE COST OF THE STRUCTURAL COLUAM4NS�
BEAMS, FOOTINGS, AND- 211
FROM BASE BID.
TOPPING SLAB AS DELETED
1 THRu 7 SHOWN ON SHEET E-7. ALL CONDUIT,
WIRES MULTIPLEXER9 MONITOR, ETC. SHALL BE INCLUDED
IN BASE BID.
ECURITY
NGS TO INCLUDE SINGLE AND DOUBLE
BUNKS, 4 MAN AND 3 MAN TABLES, STOOLS DETENTION
DESK, AND DETENTION COUNTER AS SHOWN ON A-15.
NEW ASPHALT AS SPECIFIED AND SHOWN ON SD -1.
0
0
OMSE
ITEM I DRAWING 1-i4; NOT9 1d' YULL ime FUL PLITE PAJNTED law WELD d!
GRIND SMOOTH ALL JOINTS.
ITEM..,2 DRAWING A-4; REFERENCE DETAIL AJAw90 THE STOOLS AT BOOKING
COUNTER SHALL BE 24" TALL, TYPICAL OF (3) STOOLS,,*
ITEM3 DRAWING 5D-3; REFERENCE STAIR PLAN B/SD=3: THE NEW STAIR IN THE
OUTDOOR EXERCISE 137 SHALL BE SIM AR TO DETA F/SD=2.o THERE SHALL
SE 6'-O" GUARDRAIL WITH HANDRAILS TYPICAL OF (2), SUMffiAR TO DETAIL
2/SD-3.
ITHM4
ITEM 5
SECURITY WIRE: (INCLUDE IN BASE BID) FuRNLSH AND INSTkLL 160 LF oF
SECURITY WIRE AROUND PERIMETER OF EXISTING PARAPET. SEE ATTACHED
SPECIFICATION. SEE ATTACHED DETAIL.
APPROVALS:
- COLUMBIA PAINT COMPANY IS AN APPROVED MANUFACTURER
PROVIDING CONFORMANCE TO SPECIFIED STANDARD.
ITEM6 REMOVE ALL EXISTING FLOOR FINISHES (VCT, GLUE, CARPET) SAND
BLAST E.XLW- MG FLOOR SLAB TO REMOVE PAINT & GLUE.
ITEM7
ITEM 8
ITEM9
ITEM 10
womom
ITEM 11
W. ncDows Aq Bo J & K Hum M. ATERUL AS PER DETAILSe
R
40 ;4bli loil 4k I
MEciEtAMCAL ADDENDUM (SEE ATTACHED)
ELECTRICAL ADDENDUM (SEE ArrrAc.HE. D)
CLARMCAnON - CEILING IN ROOM 109 TO BE ACOUSTICAL TILE.
4
—END OF ADDENDUM—
f7�+ffrd��
16-39
REGION VII
JUVENILE DETENTION FACILITY
Proposalof.......M.P..
(hereinaf�er caped Bidder, a corpv�ation, organization and existing under the taws of the State of Ida
partnership, or an individual doing business as
-6
To: Madison County Commission
Rexburg, Idaho 8344U
Gentlemen's
The undersigned, in c�mpliance'with Your invitation for bids for materials and construction wo
thethethe.0
Region VII Juvenile Detention Facility having examined the plans and specfieations
documents and the site of the proposed work, and being familiar with all of the conditions suffvunding the
requirements of the proposed projects, including the availability off' materials, and supplies, agree to cvmplete
the work required in accordance with contract documents, with�ir� the time sit forth therein, and at the prices
stated below. These prices are to cover all expenses incurred in providing the materials and/or installation or
other construction work required by the Contmt Documents which am bid, and of which this proposal is a part.
rk required for
with relayed
B*dde� hereby a�ees to commence work un
this contract on a +da.�e to be sp�ccif�ed in a written "Notice To
Proceed" from the []caner issued no later than (1U) days after the contract is awarded, and agrees to fully
complete the work within the calendar days requited from the date of the notice to proceed, and will forfeit
($200.D0) ger day for every calendar day beyond the day of substantial completion.
Bidder acknowledges receipt of the foliowing addendum:
Bidder awes to perfonn all the work required and as indicated and described in the specifications and shown
an the drawings, and proposes to provide all material and/or installa�ion, in the time stipulated and as necessary
and incidental to the work for the bid price as follows;
ALjD..-W� `E-0
The bidder acknowledges that included in the base bid a lump spm of $25,044.()4 to be, used at the discretion
of the Architect for unseen conditions, building peffnit, special inspection, testing, etc and construction
management services to coordinate the efforts of the owner and Geneml Contractor. It is understood that the
Y..-.F:t t11AX C~�nAr.q] C[ltltf'aCttl3' ]S lI1CILIC�� lit thebase bid.
�J�Zjill. L{R1V y � VLiiVM'\i ova vi�.Y vY�t+oaw► r����++.+��— -- ---
IF
Region V111
Juvenile Detention Facifflity
fl
September 1997
Bid Proposg
DOUARS(I
BASE B
ALTEMATES, L:
(outdoor recreation As DrawO DOLLARS($
#2 (outdoor Recreation Revised
#3
fStructaral Items) �LLARS($
* 6 "ift M =
t a is
0
LLARS($
M 0 lwd�l OR
Upon receipt of notice of acceptance of this bid, the Bidder agrees to execute the contract proposed by the
Owner within 5 days and deliver Ownees protective bands, as requires, in the. prescribed form and in amounts
of 100% of the contract pnce for faithful perfonnance of the Contract. The certified, cashier's check, or hid
bond attached, in the amount not less than fire percent (5%) of the above bid sum shah become the propeny
Of the Ownerin the event that the Bidder faits to execute the agreement after the Owneri"ssues the "Notice of
Acceptance" to bidder and/or the owner's prolective bands as required as not delivered promptly, as liquidated -
damages dor the delay and additional expense caused thereby, The bid security is attached in the spm of:
DOLLARS($
The Bidder acknowledges that the time of completion is of the essence and will agree and accept the liquidated
damages provision of the contract should they be the successful Bidder.
Bidder agrees that this bid shall be good and may not be withdrawn for a period. of forty-five (45) days
after the scheduled closing time for remiving bids.
Bidder understands that if he does not answer all of the questions, and fill out all blank spaces provided
for answering, the bid maybe rejected as an incomplete bid.
T1W SCHEDt�:
Bidder agrees to complete the work within 180 calendar days from the Notice To Proceed.
CTORS MENTM
PLUMBING:
MECHANICAL: LICENSE
r
ELECTWCAL:
OTHER..
Region VII
Juvenile, Detention Facility
2
September 1997
LICENSE
Bid Proposal
Bidder understands that the owner reserves the right to rejector accept any or all bids, or combination thereof,
and to waive any infonn.ation in the bidding.
Respectfully submitted,
(SEAL)
NAME OF CONTRACT OR PUBLIC WORKS LICENSE
If bid is by corporation
Region 'SII
Juvenile Detention Facility
BUSINESS ADDRESS
B,Yq P.
SIGNATURE OF AUTHORJZED REPRESENTATIVE
3
September 1997
Bid Proposal
aAWS
Ap
ef B REEP ARM
+1k
0/0
-ow - r
RAM
sTM SEMCACAMVMY INTO
L
IL I M .6 1 /0.7 " = I q � C�
ol
rt
op -
op
00
ol
10
:LFr
I
-Mmlwi
A
a7ro,
0CP
m-4;llrwp,ATllbh:
;N zavio;
L--
C�-j
I
Ext
PC
5T.
PL� AN
4m, .1 ��
SCALE: KT-sS4
"Is -
so
do
gl4d 4; m - -
A" r)EMo y*DW IN TM OUTDOOR RECfREATION ARZA ALL
E"Ivl- R MaM CoONTRACT VOCAk4ENTS
A5 S-HOM4 ON THE 50th`"
EXCepT T�E, REMOVAL OF THE POLICE STATION Y4ltVOAS.*
HINDOA TYPE 'J'5HALL 5E VeLETM�THE EX15TIN& Y41NOONS
=111
wriALL REMAIN.
id"
AL Amok -
46
Ap
LA C� y +
f
�m i
roi 10-A
JMIL so -WaNC�mlAiw
�--�A dF
41N
m
nwON
.a "dP ,
oat.
IO -30—Q`1
Page
0
r, 70i � I tpp�l I t4- AU lk�
�'a_' 1 z 2_ ►� '
tDE'T/UL
sscuzirr ratz�
NORTHr=LMY,4TION
SCAM, I/bu a 11 . ON
We SOW
MP
at A
EPE=TAI
x/LLEi N.TS.
AL11"=RNATE # 2
(4) FOR
Paga
I %W`
ns
A6
- 'F
. m owl
60 _
v
N.
Tom'' RAID
Fr- r ti
f F g
,�+ f } _ '
y •-�N{lair
r; #
v
- r+ '-r• /'� ate+ y+vry •/R % �'4
Jr qL
-•��
f�
4.
F
%r
-
r
i f
r -4 r i'
_Y r7•e
WTE37%tvEDIATE RAMMIL
•
'r
r *
•�ti
e t � � �.' �
r� r f
� �r4 �
++ F� ILL yrte' A.r
P
�#
jr
1n
Jr�_a
r e
4
SIN LIM...
IL
F• T r re i L
�y� •a ;� }�
X.
•q •moi
,
'
3 /
y _ + L -
•4e r
+
• t a %
L+ •
YL
fY`
~b 11y
�,",'� 'C
°. N F
AL
RAI
a +
, e. _,.
.
\ ; 4
F
41 �_
JL
~ %
_ er
.
kr� f +
r` V.. -
} d
�.'r .. k L YN P
riv 4
Ll �
a r3k
,r
L
s y
P
Le %
+ f
f P
•• }`J _
I %W`
ns
A6
- 'F
. m owl
60 _
v
SCALE H.T.5-0
ASSOCIATES
OUTDOOR EXERCISE
ALTERNATE # 2
Job No.
045
oar.
10-30-9'7
Page
A.
e40.
-
i f
r -4 r i'
_Y r7•e
roe ��..� - +
•
'r
- =+•
e t � � �.' �
+fir
•�
P
1n
Jr�_a
r e
_
t
•q •moi
'
3 /
4
F
r.
P
SCALE H.T.5-0
ASSOCIATES
OUTDOOR EXERCISE
ALTERNATE # 2
Job No.
045
oar.
10-30-9'7
Page
SECTION 02830
sEcuRITY FENCING
PART I GENERAL
1.01 SUMMARY
A. Includes But Not Limited To
i. Furnish and instil complete fence as described in Contract Documents.
1.2 REFERENCES
A. American Society For Testing And Materials
1.6 ASTM A 123-89a, "Standard Specification for Zinc (Hot -Dip Galvanized) Coatings on Iron and
2.
310
4.6
5.
6.1
Steel Products"
ASTM A 153-82 (1987),
Hardware"
ASTMA569-91a'"StandardspeciticauonNUMI I LAUMM kV.P L a MU&MMU4 Percent),HM-Rolled
Sheet &Strip, Conummial Quality"
ASTM A 570-.90,14Standard Specification for Hot -Rolled Carbon Steel Sheet& Strip, Structural
Quality"
ASIM F 669-91, "Standard Spec"cation for Strength Requirements of Metal Posts and Rails
for Industrial Chain Link Fence"
ASTM F 1083-91, "Standazd Specification for Pipe, Stwl, Hot -Dipped Zinc-Co�
(Galvanized) Welded, for Fence Struch="
"Standard Specification for Zinc Coating (Hot -Dip) on Iron 8c Steel
2.1 MATERIALS
2.2 COMPONENTS.
A. security Wire
1.
S', ngle Coit coacatinn, IS" diametcr, fabricaed from AISI 430 stainless steel with a minimum
hardness of rochvell (30N)37. 11e tape stall be .025" thick x 1" wide prig to fOnning. Each
barb shall he (2.5 f 0 - .10 tip/lip) in groves of four spaced on 4" cantata. Coils shall have 13
barb groups per- loop, and each cell stall have 311oops. The tape shall be P"MnOdY cold
clenched a minimum of 230 degas around a hot -dipped galvanized zinc steel care wire having
a&amew of .098" and a mteinimum nsile strength of 220,000 psi is accordance with ASTM
10
A-764 finish 2, Class H,.Type 3. AdjouungIODP-s will be clipped together with stainless steel
CU ps, creating a concertina affect Tbr, stainless steel clips shall be approximately .065" Uucr
x .375" width, capable of widutanding aminirnumof 200 lbs. Pull load, when deployed the coil
length shall be 15 4 4
PART 3 EXEcvTzox
3.f INSTALLATION
A. Security Wire shall be installed by mechanics skilled and experienced in this type of work and in
accordance with Contract Documents.
Region V11
Juven'tile Detention Facility
I V Z, 1160
1
September 1997
Security Fencing
V
k
REGION VII JUVENRE DETENTION FACHJTY
Mechanical:
mom
1. Sheet M-2: Delete the three blocked details on this sheet.
2„ Sheep M-3: The 4" drain line sown connected to alley drainage system shad be changed
to b" size from the connection of the roof drain dine to the alley system.
3. Sheet M-3: A. it is the Contractor's responsibility to evacuate the existing condensing.
unit that serves the basement chiller. Remove it from the roof, protect
it during construction and re -install the unit on the new rood.
Reconnection, charging of refrigerant and verification of operation is
also part of the Contractor's responsibility.
B. RT - 1 shown at the sough east corner of the roof should be RT -2 to
match with unit shown on Boor plan on Sheep M-5.
Specifications, Section 1597 1:
Electrical:
I . Sheet &50.
The Honeywell T-7300 thermostats specified shall be the
1997 new style identified as the "Series 2000 Commercial
Microelectronic Thermostat" Honeywell T-7300 F2010
with associated sub -base andremote sensors.
Install two hype fixtures on south walk (of courthouse) above roof of
juvenile center. Laca�e �xisting power circuit to ZD amp 1 pole breaker in
Panel "E". Control with P.E. switch.
2. Specifications: All devices and cover plates to be white.
3. Provide 120 volt circum from Pani "E" for air compressor in boiler room {Far Door
. - Locking Systems provide receptacle cord and plug,
18622
208-233-0529 EIS I NEERED SY5I tri
PACKAGED ENGINE GENERATOR SYSTEMS
1. 1 Soope
pnw4ide, 1 11, and ameXance tW a emplet8 aW C4*rat�ff EmefgeW/6bndbV eledde
gem ng systen inolLd adl dwkes and eqUI&OPAWMI at speoffied he*R as shown on tho drawirgs,
or reWmd for the s e, "11 be new,factory b*ftcL anddelivemd ready for
Installatim
1.2 Apprmed Mamftcturers: n an he plans arq
'-"qUpMeM d6mynentatior% siv
*es cjeWdbed In Ns epeeftmdon " st"ON t
Is Wed bV Onan CorpmatiM Mirmapolls, Minmeots.
'tat data, as qWMW hereiR otawly dwding
" �' �-' 4 �' a �F'. 7 #"" 'r' The
' '� # prup)W
i
At
Ll tiam an&or
be subn*ed to the "rou or Vahbe for appmal/chmppm" rot Im dw I a days PdW to to
"ed bid &te. tf apWWO
r&As",,
subra ft foilawinq i, wfth the pmpml paokage fbr mWw and evaluabon 10 days prior
jo Wva*id bid d
pamgraph desoribing
ffe
dN1 - n ft spaOled w4 ft
�mwn bdww
�. pwWWIng KUpmnt (whw
i rakm of ftL gyvMor 6d181Moj%W aM &=aW hardmMa I p4m and dwafiow dvMngsA
t
S f #
spwioaftl
Ind
=&m of tt* mwmt Wd
e office
staffed
ffY..1"d M .IIF �" * � '�' � �_ � •� �
Provide servW arga i- on date and marqPower. lndftte typWal respome Unv for
eMergwwy * Ti,e
typical soenarlo for en.envrgercy aeMce callik
1 .3 SUbmftls:
VMn 10 dup aftr 8w9rd of 00nftCt,, PWVidB fik Set$ 0 to tolloMng IrtmmUon tor review:
Mamifaeb"re. product fitemtve and perfomiance sffdert to ve* wryOiance to
A a -Ph Im. coorrolau"
paaKpph
F -a Vwt ication UUM&Wred des0bing the
5-9- 1 %F
ImAT . MAlk b
*VmnL
eeek' 1 1i1 ! 1. R W and ft�i �•M&MACtUfeft 08f@WSW Of t*pe tegriq
*+ F�wami* dourroft.
1Shop drawings OMng plan and e(evdW views wb G&Ned Ovemll cRMembrs, 98as wiring, Wemonmdian datails.lnte����� wimng dagwns shcwIng ali eAe oomeotlors reqAred; w1h VeldMeN te�nals marked, in a cornWwt point -to-pdrt r.�fazftahzvs Ingallation Irstmodoml.
1., 4 Waffa*,'
S I be provkJed for all p*ducts aohV defecft in mteftle ancJ worWraraNp for one year period
fr6m the slad, -W da
te.
r r' ar03 Tr FAII
91
- - k�
+ O i
2.7.1 Prototype Tests arK1 Evaluation
I
i
a
`
I
.1
14,4
.
y
I
! .... • a'#T
-w
k '
r
ftwe
deplaconvft,
ffmto*W,
W1
IuWcaffion
oil pitrva
i
maps I
_MAb
,?-Otjl
ftm
lubricaWn
o1i
fliters wfth
roplaoeaw,&
LAW son
-on
oafttv
eWrnuft
and dirmtJok oil Wei
i
1
u
liu
An
er#ne
a' "wan, umhardcal,
pwRive
d! werrott
fW
puW-
RaLr%l000ble
dry denwt
air c6amr,,
r
Ftawlble
ti 'k'
lines.
a
- w
-A
L
mourted battery
charging
aftemator,
37
•
21
f Afterrotu--
The
F V
aftemator
"I
be,; syrcftnous,
fw pdej
20 -11L
&-rwotvina
W
dd col*ruafim
m-
sinoto
w-akd
firQ
Wr 000Wd ty
a Onxt
Wve
=tWuWl
Wmer fan, " clnxAty
'WIN prWLbicated.
oarwoted
toffm
"re
wth
IMF
.
AR Insjagon
shall
tarTpDmture
Clus
M
Pit
oil I
i
.�
*
.�
t •
A
f
14
w P1411
V
CIA
9
R
o
I'
. IF
—Ad�
4 . 1.
d
w f # W
yy
ai i
- -et
i #dr
�7
k
R
�
Op
w�
dp
V11 w
s
mT
W,#
'F
i
a be
t
: �r •
�•
s '
+.'
M�
it
IF
dr
a
It
■
_
_
_ _coh
JL 97T.
1 :6171
ekx&kk
t"ft0e)
cwm
ftwe
deplaconvft,
ffmto*W,
W1
IuWcaffion
oil pitrva
_MAb
,?-Otjl
ftm
lubricaWn
o1i
fliters wfth
roplaoeaw,&
LAW son
-on
oafttv
eWrnuft
and dirmtJok oil Wei
indk:gdor.
An
er#ne
a' "wan, umhardcal,
pwRive
d! werrott
fW
puW-
RaLr%l000ble
dry denwt
air c6amr,,
Ftawlble
ti 'k'
lines.
Erone
mourted battery
charging
aftemator,
37
•
21
f Afterrotu--
The
AC
aftemator
"I
be,; syrcftnous,
fw pdej
20 -11L
&-rwotvina
W
dd col*ruafim
sinoto
w-akd
firQ
Wr 000Wd ty
a Onxt
Wve
=tWuWl
Wmer fan, " clnxAty
'WIN prWLbicated.
oarwoted
toffm
"re
wth
ftC1
Wtge
.
AR Insjagon
shall
tarTpDmture
Clus
-I IQ Crglrle-4+Brwra[ar .pec wrnM:
NEMA 1 enclosed oontrot panel shall be t1'punted on 1
'he control shalt be vibration lWated and prototype test
order the vibration cordHons ernaurrtered. The genera
DllcwlrC featurm and fundkn,
1- `7 Fa
t
r.
}W �� #
rt - P, 01 t V 2
d
Ir *
#1 ad
4RODi
L ilk 11
.,.�'doe
I jr Ilk
AN�.A�a �JL
iOA5,-2RESF=T6WZrt.!.
i-.sinerator 9& aftef K Mis ahl dbwn for any fauft Oardfian.
nm- panei u, I ip ia;;ucn T
.1.5.3 Pt'AIEL P -AP GWiRA 37WI
Chted power.
ff
IG aM-rator "Ir 'AC;
a, Ifta 1 41 1
rid
no: i ria
CIP"Si W11 I &ATIV-1
Tiutriry 14 IILTW�Z �A;ikJl
foikYMN fea1
and fune aU"41
r7 rF 7P PY
fC4
46 Amicg AC
Voftnjeter, dLial rar!
dual fanae, 90 dagw
scale:, 2% a=racY;
Amlog rrequemy/RPM
meter. 45
1350 m1950 RPM,
90 degw scmde., +1
-.9 0.6 H2 a=xacv.
Seven pmftlan
edW awftch
wfth OFF pmWon
lay
to allow rrotw depWy
and voftage In each
Omwator
ger*mtj
uxtv aIr'.11
bie for
ft Aamm scedfied.
0_ _
a i ;!�- rib
bi
i
no: i ria
CIP"Si W11 I &ATIV-1
Tiutriry 14 IILTW�Z �A;ikJl
r7 rF 7P PY
fC4
er4fine
oH
pmwe
gmW
ena
e 000a
g
guaW.
"ne
n
Ouve
rxrrimr
L
h d
3 ■n
(haum)
betteiv
voftum
(DC
Vafts)
it A
LIP'
41
0
dp
�' � � 4+
� SAF•
! # �
P
V Ir Mi
1
k
d
W -1i R1611
a i ;!�- rib
bi
w6 or4t.f..i
no: i ria
CIP"Si W11 I &ATIV-1
Tiutriry 14 IILTW�Z �A;ikJl
fC4
er4fine
oH
pmwe
gmW
ena
e 000a
g
guaW.
"ne
n
Ouve
rxrrimr
P
haum
3 ■n
(haum)
betteiv
voftum
(DC
Vafts)
rhe oximl wdem pmvided WWI irdude a ovde om*ng sWeM wtkO� sMI be for 3 omnldng
z6x% of 15 moonde "0% %ft 15 s000nd nomr4drCpaAods_ F911tooWsha
�� *1ji r�� *. "�.a �� r' a Tm� ���'��`' +�� Ism t �'" �� � �i_ ���'. m , tot , as ti +� f
IF
Q" OF
.�. c
a !„#JIK S WIA'.69
i� ��iern �rk�lf
ale In ptppp�rtic
1b`I9-�
v , x L
i ..�#
a,p -r&4 Ide the foil oyAng feaUes In the oortd systm
do F= IV, ft oonv= alarm cartact set MW 2A IQ 3OVDC
alarm or &Udown omd1tion on Idle rator eat
0 Cft se of ooroate fated 2A Q VVOOC to irdcate, genera
-k swvfl urux,.,te when _K.
and fma-mnw are
t1rdMM,
A fLzed aftip
UM. DC pcwer
runrung.
A ftmed 20 amp
_ shall;
be
f
powr � T
2 a 1 -P 5 Ba" I.,
rhe emine -Qen&*i
between Go�'lpGmtv
raits. Vibration isi
0 #
FYomm vwntm- * miaccnea
all beimmune from
and provide a pu��e wig
a torque -natc
fnm.iip.ru:v hpiltm a
a
Pa , *-V.. 1 *:-�4 a
JL
OW
4r IF
L
W, 172 4
3
PIP
1b *IP
"*u All
1 VAL
L k -
Vii'-' =I41 1RAem;geifIIt'd It'--31I.MF
I
61af.&
0 7�m q AL
6L A. ELI
M ML
ISO.-
IF-
o� IE V 16
-
;
,.
_
7
The
i 7!rs shalf be '';
1dwt1aVWUcW- gm -f.
rdrQ
4414 9W
it
mnufteturms r9ownffmwxbU"
.-r.
ir
X, 1.7.3
SUrfing
pm
�,.tarting
betlAry
�•
T
f
IL
Q" OF
.�. c
a !„#JIK S WIA'.69
i� ��iern �rk�lf
ale In ptppp�rtic
1b`I9-�
v , x L
i ..�#
a,p -r&4 Ide the foil oyAng feaUes In the oortd systm
do F= IV, ft oonv= alarm cartact set MW 2A IQ 3OVDC
alarm or &Udown omd1tion on Idle rator eat
0 Cft se of ooroate fated 2A Q VVOOC to irdcate, genera
-k swvfl urux,.,te when _K.
and fma-mnw are
t1rdMM,
A fLzed aftip
UM. DC pcwer
runrung.
A ftmed 20 amp
_ shall;
be
f
powr � T
2 a 1 -P 5 Ba" I.,
rhe emine -Qen&*i
between Go�'lpGmtv
raits. Vibration isi
0 #
FYomm vwntm- * miaccnea
all beimmune from
and provide a pu��e wig
a torque -natc
fnm.iip.ru:v hpiltm a
a
Pa , *-V.. 1 *:-�4 a
JL
OW
4r IF
L
W, 172 4
3
PIP
1b *IP
"*u All
1 VAL
L k -
Vii'-' =I41 1RAem;geifIIt'd It'--31I.MF
I
61af.&
0 7�m q AL
6L A. ELI
M ML
ISO.-
i � a •ate � # �i R
.7� 01 V
YY�
r
s 1 rt
# ■
XhaW
mL M -r
_
7
The
i 7!rs shalf be '';
1dwt1aVWUcW- gm -f.
rdrQ
to
" gereMor
mnufteturms r9ownffmwxbU"
.-r.
ite
X, 1.7.3
SUrfing
Cortal■ flee,
�,.tarting
betlAry
ba
cakAWead artinxM type, 12 v(* DC, t
W -Y. firr aafk
i � a •ate � # �i R
.7� 01 V
YY�
1-eIt:;_--4
a
ueromtor
-
in
cirou
i
iareakm
.-r.
ite
circuit
brmkw.,
sa
qromted &M w1rect
UL
lieWd,
mokled
oase
type
wtth elect
Ap
urit
mted at 60affVsl
3
1208
vofts. SLbmfttmk
shaH dem-orsWe
that
the ofmW
bmaki-!l
6-rovi
N
, for
dre
•tor by +
rWm
of
tdp
ohafacta
o of
the bnmkor
vith
the
ftr I damge
duuvUrfetic
of #* ateffator.
MeW
droUt
bmakers
shidl riot
ba
:-Cceptable
far,gverator
ammmA
"ecWa
LA
T, 7.2 ReffvAe
Arr"rdaW:
doNvide
and
irsWil
a 2D44ft
D made
alarm arvnuid*or
wfth ham
WaW
as shown
on the
trewirqa
or In a k�=Uon
whWh
can
be owworierIdlY
mmkorod
by foofty
nnal. The
mnote
it
�' � _ � ! ..
.� -. � {•
_ l �l _ �
Ljail
a _
ML
_ i �
-e vim -
_. � `_: rafjw
f1wr
%1 f
11 PA
Sti . _ �-• � �
Ila ._ . � _.
1-eIt:;_--4
a
Af%-P - 4--p I
FIE: 1E
-Sol i]f- I
-ir IF
IF IF F4,
W_ Tit
AL
_ + ��-
11(41. %dd6MF
+ MITI
u
jy
Ir
10 Wr 41b
IV
-
+F
r d.
Z g .KPW `
IL
t �
a $ f
F 4,•# 46
a
AUL
t�41
Is �T;r P 0.
&.P_: 1181 i
-I OPCold
- -A AIL
_
Section 2.0: Prod uds
2.2 Tran r Switch �qui Prmnt:
Complete f�p#oy a mbieCi nr egllipomnt with eiee#ictn[c contrd des"gred for mr9e voltage
160100n, YoltElQ% sensors 0n both sourceq poElffive mecharica1 and eleoiiioal intarlaoWng, and
mechanically held cortucta
2.2.t Project Dmwi rigs:
Refer to the pnojed drawlngs for speaitaatiQns on the sizes and tVpes of tmnder witch equipn��t�
withdand and atailng ratings, number of poleA voltage and ampere ratinmenctosums, and
aoQe dea
i
bwitah sha►i be rated for 60 Amps, 3 phase, 4 wile, 3 pole, 60 hertz, in a NEM A 1 enclosire.
Main powertranderoonta shall be rated for 800 volts AC. Tmnder "to -hes Shall be rated t4 carry
100 pervert of ratedcutrert contlnuoudy in the enolosire. Cirouk brezjWr type tmn ravitchesdo not
meet thisspeoiflcation.
Transftr a�Mbo[7es iha11 bre continuously rated In ambient tempe atures of 40 to +5 0 depress C, celatnre
hum I dfty up to 95 9& (no n -o ondend ng), and a Ititudes u p to 10, 000 feet.
Tran r avltah equlprnant shall have a witheFand and clodnp rating (VCR) In RMS Symmetrical
amperes greater than the available fault cunrertadiovyn on the dra"*ng&
2.2.3 Conatuotion:
T raneftr aMto has Mal III be doublethmw, eleCMoally and meohancaily i ntadoc Wd, and meahariaalty
held in both poMtona
Provide one Finn A and one Form B auxiliary contact on each mUrr, o rated by tmnder e�ri�h
position, tatted 10 e�rips at600 VAG -
EW*AM shall be UL listed" NEMA 1 rated. The enebsm shall pwide NEC;wire bend1 ic
transferowftoill-
The
when both sm-rces and #* ked atre all conneoted from eftr the top or bottom of the
2-2-4 AtAoa*tic Cortrdriv
CwtrcR "jibe sdW wet&
to sind Wied for it high kyel of immuNty to pmer lire urme and
irarsierds, demnstrated by tW to 1E EE ftndard =41 and M.45,
r .011ACC,_ '
-1W
sensor,2 A 71-M
AtAo� iml-`- shall laloml the "ne -Puenemtor set to sWrt upon sigmi from nornm I sourag
Sdid-filate time delay -stark esb _ from
0 to
6 se=
dh(fedory
_! at
s _ k shall
avoid nukance start mum, E ey starting oortacts "11 be eflver, dry type oxWete factay
7F
wired to a fieW *I'LNng termingal blook, I
7..' may• _ — — �_ ��� — t� Tf
G -4ir
i
L Ad goo is 4
FP
rMe"alk.;11.1 � � � , P,
T -he wnM sMU irdude WoUng dqyosW
, W step In the
sequanoe of cordrol ftxv63m, and to indtoate Pffese W
0
as folIMSE
' y 'AI -.
COM
154 171 ai W -W
•571, M .6 9%. %A br
® r a
_ _ _ ` _ _
2.2-5 F Panel Dft=411f
L_ err p FFmLi-'lug
Test " Sim" t" roaml pcwer loss to oortM for tesUrg ef wmrator sa. Cortras sMi I pwft for a
t wfth or wkhmA k3ad trwWer.
RetpuipmW MomertmVPUS
ft-M,
rar# 3 m
, ff ia"ItabW.
PT&AJe D4ype swftch poefflon. and soume available Irdoator lanvs on ft fmnt of the tmnder
switoh
oebi,W.
shall2,27 Chatipr. PrwM a fkat chaMe battery ohaW rated 2 anVs. DC 0UW Vokaw
shall be as re%Ared for ft O"ng bafteAm. An ammeter shall display ftrging wnnt The baUery
charger have a °
3. 0: ExemAlon
3.1 installation:
10
1"Iled bv ft 00rftCtOr In ao=darw wth firW
&bY&Ws and oontract
dOGumrft. InstallatOn Shatl =YIPN- with ap�lioable state and local .s as reqUred bv t
awioft having iungdMon. InAall eqtx - Ment in &=rclarlce w�h rMrUbotureft Imtruchom orm
irishctlom irdudeW In fte fisting or labeling of UL listed prodWs.
Installation of eWpmt shall inolude fw*Nsfing and installing a between
412
all MjOr eqLipToEml PWded for the ortwafte Mwer slystem The
*xtmdwshall
4
irte=nratno widnaWwm
nt 4+ �� i (when
reaked), un&
r te p
M*Awroem 8"far. 1W
ervi"al'on of tM
liq
F:qtmpmt shail W -na+a L&A n CUT,
hoL":080rlo 08CIS MAWR t ftil be
Mrnthenfly
fastered to the Pad In aacordame wM M-miaoturer's !Wrwfions and selamia reorenvrfts of the
EQUPMert
OW1
to inftWly sti ed and
operated
peited b ` pesi l* fir O the
�_ � e
f I T
All WJPMS(t SJUH be O"kmlly Impeded for danWe. ScmWm and Ww h6tallation dvrmQe
.9hall be reMired to final I PMY system teafirv%
Vu. ■ y deaned
+ all
drt and owvdnx�lcn detwis pdor to final tesflng of ft
ti
tem,
3.2 Factory 1-w
Equipmert euVied shall be fulty tested at the twAM for function and perfwMnOet
FadOrY tMtirQ Wte wftnvmW tV the
cwner and o _ _ �
Will be ft respoWbility of ft cwrw and oormultirg eroneer. S jar irm I emem
res m for teafing.
- i fir*' +fes #' �i G rf -
r� 5 AL.. ti t ti
ver R. i fad"
tftts-
shall
dhpy" Factwy A- --jL
tumv eMl iWu& a oon"ete funotkwW test of ft tmnww s4oh oonWsll
ir"udbirQ call of the vobae sermm.
3 On ah9fte Acmpwnoe Teat
The OW*Oe Irstallation shall be tested for empflanm wM the specy=tjan f(gk*rjO
=70ehM of 84 ge wodc Tesfing i of j Mfgcturer with
wPlm-d fUW UWied by, Cortmotor, The; En�neer shall be roffied In WVanm and rahall have the
00bn tO Wftr*W the tests'.
r
' � ta aW OX*PWM tests
to be cod Md o ''
�■ a "ONd
rVd test, a two hwr
bad test I and a one app;rated load pickup test in aoxgdance. wth PPA 10 P I a resistive
bad bar* and nwke teMPMrY mniWons for Ml kzd tegt, if mmssM.
11
IL
R-
Y f _
OIL
7